CC BY
8
• 7universum.com
UNIVERSUM:
, ТЕХНИЧЕСКИЕ НАУКИ_июнь. 2022 г.
ANALYSIS OF THE AMOUNT OF SEDIMENT IN POMEGRANATE JUICE
Zilola Madaminova
Assistant
Namangan Institute of engineering and Technology, Department of food technology Republic of Uzbekistan, Namangan E-mail: [email protected]
Sevinch Sadriddinova
Student
Namangan Institute of engineering and Technology Department of "Food Technology " Republic of Uzbekistan, Namangan E-mail: sevinchsadriddinova780gmail.com
Baxtiyor Mexmonov
Student
Namangan Institute of engineering and Technology Department of "Food Technology" Republic of Uzbekistan, Namangan E-mail: baxtiyormehmonov85@gmail. com
№ 6 (99)
АНАЛИЗ КОЛИЧЕСТВА ОСАДКА В ГРАНАТОВОМ СОКЕ
Мадаминова Зилола Тохиржон кызы
ассистент
Наманганский инженерно-технологический институт,
кафедра пищевых технологий Республика Узбекистан, г. Наманган
Садриддинова Севинч Шухратжон кызы
студент
Наманганский инженерно-технологический институт факультет «Технология пищевых продуктов» Республика Узбекистан, г. Наманган
Махмонов Бахтиёр Икромжон о'Гли
студент
Наманганский инженерно-технологический институт факультет «Технологии пищевых продуктов» Республика Узбекистан, г. Наманган
ABSTRACT
This article aims to analyze the amount of sediment in pomegranate juice and improve the quality of today's fruit juice. The article consists of separating the sediment from the juice or extract by centrifuging the juice or extract by preheating it in a water bath and determining the sediment mass of the sediment according to the fruit and vegetable products.
АННОТАЦИЯ
Эта статья направлена на анализ количества осадка в гранатовом соке и улучшение качества современного фруктового сока. Статья состоит в отделении осадка от сока или экстракта путем центрифугирования сока или экстракта путем предварительного нагревания его на водяной бане и определения массы осадка по плодоовощной продукции.
Keywords: pomegranate fruit, pomegranate juice, sediment content, centrifuge tube, pipette, water bath, filter paper, analytical balance, test tubes.
Ключевые слова: плоды граната, гранатовый сок, содержание осадка, центрифужная пробирка, пипетка, водяная баня, фильтровальная бумага, аналитические весы, пробирки.
Библиографическое описание: Madaminova Z.T., Sadriddinova S.S., Mexmonov B.I. ANALYSIS OF THE AMOUNT OF SEDIMENT IN POMEGRANATE JUICE // Universum: технические науки : электрон. научн. журн. 2022. 6(99). URL: https://7universum.com/ru/tech/archive/itemf13866
№ 6 (99)
A UNI
/Ш. ТЕ)
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
июнь, 2022 г.
Pomegranate is one of the fruits that were known to mankind thousands of years ago and were consumed for medicinal purposes. At present, pomegranate fruit is grown in different regions of the Republic and pomegranate juice is produced again. In order to develop the pomegranate industry, to open branches of the pomegranate Association in all regions of the Republic, to organize specialized farms and to assist representatives of the private sector engaged in this activity, production of pomegranate fruit and juice was launched at agrofirms of Fergana pomegranate and Mindonabad agro-industry and farmer farms in Fergana region. Now active involvement of foreign investments, foreign specialists and consultants in pomegranate cultivation processes, study of their experience and wide introduction of advanced technologies into the sphere are being established. In the experiment, the pomegranate consists in separating the juice or extract from the sediment by cen-trifugation with preheating it in a water bath and determining the sediment deposition mass according to GOST 8756.9-78 fruit and vegetable products.
A method for the determination of sedimentary rocks in fruit and berry juices and extracts
Thoroughly mix the prepared juice or extract sample, pipette 25 cm3 into each of the four centrifuge tubes, then place the test tubes in a water bath with the juice, heat to 85 to 90 ° C and keep at this temperature for 3 min. The tubes with the juice are centrifuged and centrifuged at 8000 rpm for 20 minutes. The tubes are then removed, carefully drained into a centrifuge, and the tubes are placed upside down on filter paper to drain the
remaining liquid. After 10 minutes, traces of liquid remaining on the walls of the test tube are carefully removed with strips of filter paper without shaking the sediment. The precipitated test tubes are weighed on an analytical balance. When using centrifuge tubes with a capacity of 10 cm3, sediment is obtained in two stages: first, 10 cm3 of test product is placed in each tube and weighed. The tubes are heated, centrifuged, carefully drained and weighed. Another 10 cm3 of the test product is added to the same test tubes and weighed again.
After heating, hold the tubes upside down on filter paper for 10 minutes to drain the liquid from the centri-fuged sample, remove any liquid residue from the walls, and pull the tubes together with the remaining sediment. All weighing is done with an error of no more than 0.0001 g. The mass fraction of sediment is calculated as a percentage, according to the following formula,
Here
m0 is the mass of the empty test tube, g;
M1 is the mass of the test tube with sediment, g;
m2 is the mass of the product, g.
The result is an error of up to 0.01%.
The arithmetic mean of the four parallel determinations is taken as the final result, with a difference of no more than 10%. If the difference between any two parallel determinations exceeds 10%, all tests are repeated and the final result is the arithmetic mean of the eight determinations.
Table 1.
Calculation of the norm of time for instrumental indicators of the quality of pomegranate juice "determination of sedimentary rocks"
Process name Lead time Standby Time Sample Number Total time
Sediment detection method:
Sample preparation
- Sample selection 0,1 - 0,1
Test preparation: -
- dry centrifuge tubes are pulled 0,1 - 0,1
- Mix the juice 0,1 0,1
- juice nature of about 150 cm 0,1 0,1
Test: -
with a pipette of 25 cm each 0,1 0,1
placed in a water bath 0,1 0,1
- heated to 85 - 90 °C 0,3 0,3
- Centrifuge for 20 minutes 0,3 0,3
- test tubes are removed 0,1 0,1
-The tubes are placed on the reverse side of the filter paper 0,2 0,2
- In 10 minutes. removed with filter paper strips 0,2 0,2
- Sediment pipes are pulled 0,1 0,1
- is calculated according to the formula 0,5 0,5
Total: 2,4 2,4
№ 6 (99)
А1
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
Conclusion
In summary, the physicochemical parameters of the range of pomegranate juice and concentrate were analyzed at the level of international standards and requirements. Technological factors that may affect the quality of pomegranate juice have been studied. Research has been conducted to determine, evaluate and improve the
июнь, 2022 г.
quality of pomegranate juice. In the experiment, the amount of sediment and extract of pomegranate juice was preheated in a water bath by centrifugation to separate the sediment from the juice or extract, and the sediment mass was determined according to the fruit and vegetable products and the desired results were obtained.
References:
1. Eshmatov F.Kh., Dodaev K.O., Khasanov Kh.T. Processing of pomegranate fruits for juices and concentrates. Zh-l "Beer and drinks". M.: Pishchepromizdat LLC, No. 2, 2005. - S. 46-47.//
2. Schobinger U. Fruit and berry and vegetable juices. -M.: Light and food industry, 1982. -472 p.//
3. Samsonov G.V. Ion exchange and sorption of organic substances. L., "Nauka", Leningrad. department, 1969. - 335 p.
4. Rizaev N.U., Yusupbekov N.R., Yusipov M.M. Fundamentals of optimization of extraction and ion-exchange technology. Tashkent: "Ukituvchi", 1975. - 228p.//
5. Rizaev N.U. Production of organic substances from their extracts by adsorption. - Tashkent, "Nauka", 1965. - 236 p.
6. Korolkov N.M. Theoretical foundations of ion-exchange technology. Riga, "Liesma", 1968. -293 p.//
7. Ion exchange and ionometry: Interuniversity. collection // Ed. B.P. Nikolsky. - L .: Publishing House of Leningrad State University, 1976.
8. Ergozhin E.E., Menligaziev E.Zh. Polyfunctional ion exchangers // Academy of Sciences of the KazSSR, Institute of Chemistry. Sciences.-Alma-ata: Nauka, 1986. -302 p.
9. Kokotov Yu.A. and other Theoretical foundations of ion exchange. - L .: Chemistry. Leningrad. Department, 1986. -280s.
10. Soldadze K.M., Kopylova V.D. Complexing ion exchangers (complexites). - M. Chemistry, 1980. - 336 p.
