CC BY
7
№ 9 (102)
universum:
ТЕХНИЧЕСКИЕ НАУКИ
сентябрь, 2022 г.
EVALUATION OF THE EFFICIENCY OF THE USE DIESEL LOCOMOTIVES 4TE10M IN OPERATION
Oleg Ablyalimov
Candidate of Technical Sciences, professor, professor of the chair «Loœmotives and locomotive economy» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: o. [email protected]
Otabek Khamidov
Doctor of Technical Sciences, Head of the chair« Loœmotives and locomotive ßconomy» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: otabek. rustamovich@yandex. ru
Jasurbek Yakubov
Master, аssistant
of the chair« Loœmotives and locomotive cconomy» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: [email protected]
Anna Avdeyeva
Candidate of Technical Sciences, аssistant professor of the chair «Materials science and mechanical engineering» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: [email protected]
Khusan Kosimov
Senior lecturer
of the chair« Loœmotives and locomotive cconomy» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: [email protected]
Utkir Safarov
Master, аssistant
of the chair« Loœmotives and locomotive cconomy» Tashkent state transpоrt university, Republic of Uzbekistan, Tashkent E-mail: [email protected]
ОЦЕНКА ЭФФЕКТИВНОСТИ ИСПОЛЬЗОВАНИЯ ТЕПЛОВОЗОВ 4ТЭ10М В ЭКСПЛУАТАЦИИ
Аблялимов Олег Сергеевич
канд. техн. наук, проф., проф. кафедры «Локомотивы и локомотивное хозяйство» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
Библиографическое описание: EVALUATION OF THE EFFICIENCY OF THE USE DIESEL LOCOMOTIVES 4TE10M IN OPERATION // Universum: технические науки : электрон. научн. журн. Ablyalimov O.S. [и др.]. 2022. 9(102). URL: https://7universum. com/ru/tech/archive/item/14288
№ 9 (102)
universum:
ТЕХНИЧЕСКИЕ НАУКИ
сентябрь, 2022 г.
Хамидов Отабек Рустамович
д-р техн. наук,
заведующий кафедрой «Локомотивы и локомотивное хозяйство» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
Якубов Жасурбек Камолиддинович
магистр,
ассистент кафедры «Локомотивы и локомотивное хозяйство» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
Авдеева Анна Николаевна
канд. техн. наук,
доцент кафедры «Материаловедение и машиностроение» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
Косимов Хусан Рахматуллаевич
ст. преподаватель кафедры «Локомотивы и локомотивное хозяйство» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
Сафаров Уткир Истамович
магистр,
ассистент кафедры «Локомотивы и локомотивное хозяйство» Ташкентский государственный транспортный университет,
Республика Узбекистан, г. Ташкент
ABSTRACT
The kinematic parameters of the movement of freight trains and indicators of the energy efficiency of the use of diesel locomotives 4TE10M on a real, mountainous section of the railway are obtained in the form of tabular data, and regression equations are compiled to determine the main indicators of the transportation work of these diesel locomotives on this section. The results of the study are recommended for implementation in the practice of the specialists of the operation shop of the locomotive depot Karshi of the Uzbek railway.
АННОТАЦИЯ
Получены кинематические параметры движения грузовых поездов и показатели энергетической эффективности использования тепловозов 4ТЭ10М на реальном, горном участке железной дороги в виде табличных данных, а также составлены уравнения регрессии по определению основных показателей перевозочной работы указанных тепловозов на этом участке. Результаты исследования рекомендуются для внедрения в практику работы специалистов цеха эксплуатации локомотивного депо Карши Узбекской железной дороги.
Keywords: study, freight train, diesel locomotive, railroad, parameter, way, station, time, speed, mountainlaly.
Ключевые слова: исследование, грузовой поезд, тепловоз, железная дорога, параметр, дорога, станция, время, скорость, горный.
With in the framework of the program for the development and modernization of the enterprises of the locomotive complex of the Uzbek railways, an important place is occupied by the solution of specialized specialized tasks related to the issues of increasing the efficiency of using diesel traction in non-electrified sections of JSC "O'zbekiston temir yo'llari".
At the Department of Locomotives and Locomotive Economy of the Tashkent State Transport University, research is being carried out to optimize the transportation work of locomotives in order to ensure the transportation of goods and passengers at the lowest cost of fuel
and energy resources for train traction, based on the theoretical foundations of mathematical methods of optimal control and locomotive traction.
A prerequisite for the implementation of the above was the traction calculations carried out for the most difficult section of the railway company - Tashguzar - Acrobat [1,2], where freight trains of various mass trains (Qi=2500 t, Q2=3000 t and Q3=3500 t) are serviced diesel locomotives 4TE10M, which were based on the equation of train motion of the form
№ 9 (102)
a uní
1Ш. ТЕ)
universum:
ТЕХНИЧЕСКИЕ НАУКИ
сентябрь, 2022 г.
where v is the speed of movement, m/s; t - train travel time, s; u - specific resultant force of the train, N/kN; Ç is the actual (actual) acceleration of the train, kNm/Ns2.
The solution of the differential equation (1) was carried out by a graphical method, taking into account the principle of maximum use of power and traction and performance qualities (properties) of the locomotive [4], which for a diesel locomotive 4TE10M, in the traction mode, corresponds to the 15th nominal position of the driver's controller in the full field of PP, the first (OP1) and second (OP2) stages of weakening the magnetic field of traction motors [3], in the speed range from 19 km/h to 60 km/h according to the locomotive traction characteristic. In addition, idle and braking modes are used.
The results of traction calculations for three different modes of driving a freight train with different masses
of trains by diesel locomotives 4TE10M on the Tash-guzar-Acrobat section are shown in table 1.
Based on the analysis of the results of the mentioned traction calculations in relation to a scheduled (unified) freight train with a train mass of Q2 = 3000 tons, the following was obtained.
1. The average total train travel time is 2.75 hours, however, a decrease in the mass of the train by AQ= 500t (by 20%) leads to a decrease in the total train travel time by 8.05%, and with an increase in the mass of the train by AQ= 500t ( ~ 20%) there is an increase in this time by 8.24%.
2. The technical speed of the train, on the contrary, with a similar change in the mass of the train, tends, respectively, to increase and decrease within the same limits, and on average, it is 39.79 km / h.
Table 1.
Efficiency parameters of diesel locomotives 4TE10M on the mountain section Tashguzar -
Acrobat of the Uzbek Railway
Traction calculation option Conditions of transportation work Train running time, min Consumption and cost of diesel fuel
composition mass Q, t number of axles m, axes technical speed Vt, км/ч general tx in traction mode tm in idling and braking mode,txx,T total per trip E, kg specific per trip e, kt/104tkm gross reduced cash costs C', som/km
1 2 3 4 5 6 7 8 9 10
1 2500 200 43,11 151,76 104,05 47,71 3621,7 132,846 36699
2 3000 200 39,64 165,04 120,31 44,73 4167,3 127,381 42227
3 3500 200 36,63 178,64 137,94 40,70 4772,6 125,043 48361
3. The total and specific average consumption of diesel fuel for traction and maintenance of a freight train on the entire section is 4187.2 kg and 128.423 kg/104 tkm gross, respectively.
4. An increase in the mass of the composition by ~ 20% contributes to an increase in the total consumption of diesel fuel by 14.53%, however, the specific consumption of diesel fuel decreases by 1.84%, and a decrease in the mass of the composition by 20% provides a decrease in the total consumption of diesel fuel by 13 .09% and an increase in the specific consumption of diesel fuel by 4.29%.
5. The travel time of the train in the modes of idling, braking and traction varies, respectively, from 0.80 h to 0.68 h and from 1.73 h to 2.30 h. With an increase in the mass of the train by ~ 20%, the train travel time in the idling and braking mode decreases, as well as its increase in the traction mode, respectively, by 0.067 h and 0.294 h. With a decrease in the mass of the train by 20%, the time of the train in the idling and braking mode increases, and in the traction mode it decreases by 0.050 h and 0.271 h, respectively.
6. A decrease in the mass of the composition by 20% leads to a decrease in the use of the traction mode and an increase in the use of the idling and braking mode [1] by 4.34%, and with an increase in the mass of the
composition by ~ 20%, these indicators increase and decrease by 4 .32%.
7. A decrease in the mass of the composition by 20% leads to a decrease in the total and specific cost by 13.09%, and with an increase in the mass of the composition by ~ 20%, these indicators increase by 14.52%.
Using the standard program of the Microsoft Office Excel series, we have obtained concise formulas that allow, with a sufficient value of the approximation reliability R2 (the necessary reliability condition is R2>0.8), to accurately calculate the main performance indicators of diesel locomotives of the 4TE10M series on the Tash-guzar-Acrobat section for any i th mass of the composition Q of the freight train.
Technical speed of the train, km/h
VT= - 0,0065Q+59,207, R2=0,9985 (2) Total train travel time, min
tx=0,0269Q+84,653, R2=0,9999 (3) Train travel time in traction mode, min
tT=0,0339Q+19,097, R2=0,9995 (4)
№ 9 (102)
universum:
ТЕХНИЧЕСКИЕ НАУКИ
сентябрь, 2022 г.
Train travel time in idling and braking mode, min
txx,T= - 0,007Q+65,41, R2=0,9926 (5)
Total diesel fuel consumption per trip, kg
E=1,1509Q+734,5, R2=0,9991 (6)
Specific consumption of diesel fuel per trip, kg/104 t km gross
e=547J9Qr0'1814, R2=0,9707 (7)
Reduced cash costs, som/km
C'=11,662Q+7443, R2=0,9991 (8)
The obtained analytical expressions (2) - (8) indicate that the nature of the change in the main indicators of the transportation process, depending on the mass of the freight train, obeys a linear law, with the exception of the specific consumption of diesel fuel, for which
such changes are described by a power function. At the same time, the absolute error in the calculations of the mentioned indicators for various conditions for organizing the transportation work of diesel locomotives 4TE10M on the Tashguzar - Acrobat section is 0.08 ... 0.72%, which ensures the calculation accuracy of 99.92 ... 99.28 percent.
The conducted studies also found that an increase in the consumption of full-scale diesel fuel for a trip on the Tashguzar-Acrobat section is closely related, first of all, to an increase in the travel time of a freight train in traction mode, and as a result, this leads to an increase in the mechanical work of forces acting to the specified train in this mode.
Thus, the use of mathematical models for driving a freight train by diesel locomotives 4TE10M and the main indicators of the transportation process on the section Tashguzar - Acrobat of the Uzbek railway provide the necessary conditions for predicting the consumption of full-scale diesel fuel and the efficiency of these locomotives on this section in various operating conditions.
Reference:
1. Ablyalimov O.S. To the efficiency of diesel locomotives on the section Tashguzar - Kumkurgan [Text] / O.S. Ablyalimov, I.R. Kayumov // Vestnik TashIIT, No. 2, 2012. - P. 42-44.
2. Ablyalimov O.S. To the efficiency of using diesel locomotives 4TE10M on the section Tashguzar - Kumkurgan [Text] / O.S. Ablyalimov, I.R. Kayumov // Republican scientific and technical conference with the participation of foreign scientists. "Resource-saving technologies in railway transport". - Tashkent: TashlIT, 2012. - S. 48-51.
3. Ablyalimov O.S. Fundamentals of train traction [Text] / O.S. Ablyalimov, D.N. Kurilkin, I.S. Kamalov, O.T. Kasi-mov. Under the general editorship of O.S. Ablyalimov // Textbook for higher educational institutions of railway transport. - Tashkent: "Complex Print nashriyoti", 2020. - 662 p.
4. Deev V.V. Traction of trains [Text] / V.V. Deev, G.A. Ilyin, G.S. Afonin // Textbook for universities. - M. : Transport, 1987. - 264 p.
