CC BY
24
№1X94)
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
январь, 2022 г.
CIVIL ENGINEERING AND ARCHITECTURE
DOI - 10.32743/UniTech.2022.94.1.12995
DEFORMATIVITY OF REINFORCED CONCRETE COLUMNS FROM HEAVY CONCRETE
UNDER CONDITIONS DRY HOT CLIMATE
Bakhodir Rizaev
Assistant professor of Namangan Engineering Construction Institute, Republic of Uzbekistan, Namangan E-mail: Rizayev1952 @gmail. com
Adkhamjon Mamadaliyev
PhD of Namangan Engineering Construction Institute, Republic of Uzbekistan, Namangan E-mail: [email protected]
Isroil Umarov
Assistant at Namangan engineering construction institute Republic of Uzbekistan, Namangan E-mail: [email protected]
ДЕФОРМАТИВНОСТЬ ЖЕЛЕЗОБЕТОННЫХ КОЛОНН ИЗ ТЯЖЕЛОГО БЕТОНА В УСЛОВИЯХ СУХОГО ЖАРКОГО КЛИМАТА
Ризаев Баходир Шамситдинович
доцент,
Наманганский инженерно-строительный институт, Республика Узбекистан, г. Наманган
Мамадалиев Адхамжон Тухтамирзаевич
PhD
Наманганский инженерно-строительный институт, Республика Узбекистан, г. Наманган
Умаров Исроил Исоцжон угли
ассистент,
Наманганский инженерно-строительный институт Республика Узбекистан, г. Наманган
ABSTRACT
On the basis of wide-scaled ingestions of reinforced concrete structures for industrial, civil, residential and other buildings and constructions of hot dry climate it has been established that under cyclic influence of solar radiation, high temperatures and low humidity compressive and tensile strength of concrete is lessening, load elastic, plastic and shrinking deformations are developing.
АННОТАЦИЯ
В этой статье рассматривается напряженное деформированное состояние железобетонных колонн эксплуатируемых в условиях сухого жаркого климата. На основе экспериментальных и теоретических исследований изучены деформативность железобетонных элементов.
Keywords: ry hot climate, air humidity, reinforced concrete structures, strength, deformability, crack resistance, heavy concrete, tensile reinforcement deformations, concrete fibers, stretched concrete, compressed reinforced concrete elements.
Ключевые слова: сухого жаркого климата, влажности воздуха, железобетонных конструкций, прочность, деформативность, трещино стойкости, тяжелого бетона, деформаций растянутой арматуры, волокна бетона, растянутого бетона, сжатых железобетонных элементов.
Библиографическое описание: Rizaev B.S., Mamadaliyev A.T., Umarov I.I. DEFORMATIVITY OF REINFORCED CONCRETE COLUMNS FROM HEAVY CONCRETE UNDER CONDITIONS DRY HOT CLIMATE // Universum: технические науки : электрон. научн. журн. 2022. 1(94). URL: https://7universum. com/ru/tech/archive/item/12995
№1X94)
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
январь, 2022 г.
In a dry, hot climate, fluctuations in temperature and humidity during the day and the season of the year (summer and winter) adversely affect the formation of the concrete structure. Intensive dewatering of concrete at elevated temperatures and low relative humidity of the environment leads to a decrease in its strength and modulus of elasticity.
A large daily temperature drop causes an uneven distribution of temperature stresses over concrete sections. The design and construction of reinforced concrete structures for a dry hot climate without taking into account the deformations of the forces caused by changes in high temperature and low humidity lead to early formation of cracks in concrete, their excessive opening, as well as to large deformations of the structure [1, 2, 3,4].
One of the most important factors in increasing the reliability and durability of buildings and structures, especially for the Republic of Uzbekistan, is the further improvement of methods for their calculation, taking into account real operating conditions. In this regard, an urgent task is to conduct experimental theoretical studies of the strength, deformability and crack resistance of eccentrically compressed reinforced concrete elements made of hard concrete under the influence of force factors and the unfavorable effects of a dry hot climate [5,6,7, 8,9].
To identify the influence of a dry hot climate on the strength and crack resistance of eccentrically compressed reinforced concrete elements, experimental rectangular columns with dimensions of 16 x 30 cm and a height of 100 cm, which had consoles, were made from heavy concrete. The columns had a symmetrical reinforcement of 4 rods with a diameter of 14 mm, class A - III. After concreting, all columns were in the formwork under wet sawdust for 7 days, and then they were decomposed [10,11,12,13,14,15].
In a hot climate, 8 columns were tested, 4 columns were loaded with a longitudinal force equal to 0.8 Ncrc, the remaining 4 columns were loaded with a force equal to 0.5 Np with an eccentricity equal to e = 0.5y = 7cm, and e = y = 15 cm. To measure the deformation of reinforcement and concrete during long-term holding of
samples under load, portable indicators based on 250 mm were used. The readings of the devices in the first two months were taken three times a day, in the following months, once a week for a year[16,17,18,19,20].
Loading of columns with a long-term load was carried out on the stand site using lever installations. Cast iron weights weighing 20-25 kg and concrete blocks weighing 20 kg were used. To establish the effect of solar radiation on the deformations of the stretched and compressed zone, some columns were installed so that at noon solar radiation would act from the side of the stretched zone and in other columns from the side of the compressed concrete zone. The expected breaking load and the appearance of cracks were obtained from the result of testing the column with a short-term load. The columns, after being under prolonged loading and solar radiation for one year, were unloaded and brought to destruction by short-term loading on the press in order to establish how the dry hot climate affects the strength, deformation and crack resistance of the columns [21, 22, 23,24,25,26,27].
The appearance of cracks in the columns causes an increase in the average relative deformations of the stretched reinforcement and the extreme compressed concrete fiber. Until the moment of cracking, the growth of deformations of tensile reinforcement and concrete in the compressed zone is approximately the same. With further increase in the load and, especially after the appearance of cracks in the tensioned zone, the intensity of the increase in deformations of tensioned reinforcement, as well as compressed concrete, increases.
The deformation of the stretched reinforcement of the column, which during the year were in a dry hot climate under a prolonged load of 0.8 Ncrc, was 10.5.10-5 under the action of solar radiation on the stretched zone, and 4.9.10-5 on the compressed zone. After the action of solar radiation on the extended zone for one year in a dry hot climate under a long-term load of 0.8 Ncrc, the deformation of the extreme compressed fiber was 148.5.10-5 under the action of solar radiation on the compressed zone - 84.5.10-5 (Fig. 1 ).
Figure 1. Average deformations of compressed concrete fibers and tensile deformations of the reinforcement of columns under a load of 0.5 Np and 0.8 Ncrc for a long time in a dry hot climate
1- after the action of solar radiation on the extended zone
2- after the action of solar radiation on the compressed zone
№ 1 (94)
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
январь, 2022 г.
Dry, hot climates increase the relative deformation of the reinforcement. In the columns under the influence of solar radiation during one year, the deformations of the reinforcement were more by 13-14% than in the columns that were in the workshop. The increased temperature and low relative humidity of the air in a dry hot climate also increase the deformation of the extreme fiber of the compressed zone of concrete. When the columns were in the shop for 1 year, the relative deformation of the extreme compressed fiber was Ebc = 65.10-5. The relative deformations of the extreme compressed concrete fiber in the columns that were under the influence of solar radiation for 1 year (at 0.5 Np) increased by 35-60% in comparison with the deformations of concrete at a short-term load at the age of 40 days.
An increase in the deformation of reinforcement and concrete from prolonged loading in a dry hot climate occurs due to a change in the elastic-plastic properties of concrete. The theoretical deformations of tensile reinforcement and compressed extreme concrete fiber, taking into account changes in the strength and deformation properties of concrete, are determined as follows. Average deformations of tensile reinforcement under eccentric compression were calculated by the formula.
N-e
s =
N Y
E Ah Z h E A 9
(1)
Here is coefficient taking into account the work of tensile concrete in the area with cracks, determined by the formula
1 -¿2
ш = 1.25-çœ--m
(3.5 - 1.8^ ) .-f-h
(2)
The average deformations of the extreme concrete fiber in the compressed zone are determined by the formula:
N • е¥ъ
(<pf + Z)hhnEh ßhV
N h
E A
(3)
^b - the coefficient taking into account the uneven distribution of deformations of the extreme compressed fiber of concrete along the length of the section with cracks, taken for heavy concrete equal to -0.9.
The theoretical deformations of the stretched reinforcement and the extreme compressed fiber of concrete determined by the formula (1) and (3), taking into account the recommendations of SNiP 2.03.01-84, were less than the experimental ones (Fig. 2-Fig. 3)
The theoretical values of the deformation of the stretched reinforcement and the extreme compressed fiber of concrete, determined by formulas (1) and (3), taking into account the influence of a hot climate, Rb, Yb7, Rbt,Ser, Ytt, Eb, Bb - have satisfactory convergence with the experimental values of deformations (Fig-2,Fig-3).
_- experienced
x x - theoretical according to the formula (1) ------------------the same taking into account the influence of a dry hot climate
Figure 2. Regarding the deformation of reinforcement in a dry hot climate with an eccentricity of the load e=0,5y
s
h
\ И-1 г М- 5
7universum.com
UNIVERSUM:
январь, 2022 г.
experienced
x x - theoretical
also taking into account the influence of a dry hot climate
Figure 3 Average relative deformations of the extreme fiber of the compressed zone of concrete in a dry hot climate at eccentricity of the load e=0,5y
According to the results of experimental and theoretical studies, the calculation of reinforced concrete eccentrically compressed elements operated in a dry hot climate should be performed according to the method Building codes and regulations 2.03.01-96 taking into account changes in the strength and deformative properties of concrete from the effects of temperature, humidity, shrinkage and swelling of concrete.
When calculating the deformations of eccentrically compressed reinforced concrete elements operated in a dry hot climate, the values of the coefficient ^b1 taking into account the development of short-term creep of concrete, for a dry hot climate should be taken as 0.75, the coefficient ^B2-taking into account the effect of long-term creep of concrete, for reinforced concrete elements unprotected from the effects of solar radiation for a dry hot climate, according to the first design stage of work, it is 3.0, and according to the second design stage, 3.5.
Literature:
1. Ахмедов И.Е., Ортщов И.А., Умаров И.И. Дарё узанидаги деформацион жараёнларни бахрлашда инновацион технологиялар // Фаргона политехника институти илмий-техника журнали - Фаргона. - 2021. - Т.25, №.1. -С.139-142.
2. Akhmedov I.G'., Muxitdinov M., Umarov I., Ibragimova Z. Assessment of the effect of sedibles from sokhsoy river to kokand hydroelectric power station //InterConf. - 2020.
3. Arifjanov A., Akmalov Sh., Akhmedov I., Atakulov D. Evaluation of deformation procedure in waterbed of rivers // IOP Conference Series: Earth and Environmental Science. - IOP Publishing, 2019. - Т. 403. - №. 1. - С. 012155.
4. Adxamjon Tuxtamirzaevich Mamadaliyev, son Bakhtiyor Maqsud, Umarov Isroil. Study of the movement of pubescent seeds in the flow of an aqueous solution of mineral fertilizers. A Peer Revieved Open Access International Journal. 2021. Volume 10, Issue 06, Pages: 247-252.
5. А Росабоев, А Мамадалиев. Предпосевная обработка опушенных семян хлопчатника защитно-питательной оболочкой, состоящей из композиции макро и микро удобрений. Теоретические и практические вопросы развития научной мысли в современной мире: Сборник статей. УФА РИЦ БашГУ.2013 г. 174-176с
6. Б.Ш. Ризаев, А.С. Абдурахмонов. Особенности физико-механических свойств теплоизоляционных материалов для крыш. Вестник. Науки и творчества. 2018 г. 41-44 с.
7. Б.Ш. Ризаев, Р.А. Мавлонов, А.Ш. Мартазаев. Физико-механические свойства бетона в условиях сухого жаркого климата. Инновационная наука, 2015.
8. Б.Ш. Ризаев, Р.А. Мавлонов, С.Э. Нуманова. Деформации усадки и получести бетона в условиях сухого жаркого климата. Символ науки, 2016. С-95-97.
9. Б.Ш. Ризаев, Р.А. Мавлонов. Деформативные характеристики тяжелого бетона в условиях сухого жаркого климата. Вестник Науки и Творчества, 2017.
10. Б.Ш. Ризаев, Т.И. Эгамбердиева. Распределение температуры и влажности в бетоне по сечению железобетонных колонн«Экономика и социум» №6(85) С. 3-9.
№ 1 (94)
UNIVERSUM:
ТЕХНИЧЕСКИЕ НАУКИ
январь, 2022 г.
11. Б.Ш. Ризаев, Т.И. Эгамбердиева .Анализ влияния сухого жаркого климата на работу железобетонных элементов.«Экономика и социум» 2021№6(85) С-3-11.
12. Б.Ш. Ризаев.,Ш. Юсупов., А. Ахмедов., В. Абдусаломов. Оптимизация режимов гелиотеплохимической обработки золоцементных композиций. Научный электронный журнал Матрица научного познания. (ISSN 2541-8084) в 12-1/2021. 13. Б.Ш. Ризаев.,О.Чулпонов., Ж.Махмудов. Прочностные и деформативные свойство тяжелого бетона в условиях сухого жаркого климата. (ISSN 2658-7998) № 13 2021 г. -с 760-765.
13. B.S. Rizaev. Strength and Deformation Properties of Eccentrically Compressed Reinforced Concrete Columns in a Dry Hot Climate. Design Engineering, Vol 2021: Issue 09. 7832-7840.
14. Исраилжон Тургунович Шамшидинов, Зокир Нематжанович Мамаджанов, Адхамжон Тухтамирзаевич Мамадалиев.Изучение коагулирующей способности сульфата алюминия полученного из ангренского каолина. Наука xxi века: теория, практика, перспективы. Сборник статей Международной научно-практической конференции 2014г, г.Уфа.-с-48-55.
15. Israilzhon Turgunovich Shamshidinov, Adhamjon Tuhtamirzaevich Mamadaliev, Zakir Nematzhanovich Mamajanov. Optimization of the process of decomposition of aluminosilicate of clays with sulfuric acid. The First International Conference on Eurasian scientific development . «East West» Association for Advanced Studies and Higher Education GmbH, Vienna, Austria. 2014. Pages: 270-275
16. Ismoilov T.I., Umarov I. Necessity and importance of using new pedagogical technologies in higher education // Теория и практика современной науки. - 2018.- №. 3. - С. 28-30.
17. К.Гафуров, А.Росабоев., А. Мамадалиев. Дражирование опущенных семян хлопчатника с минеральным удобрением // ФарПИ илмий-техник журнали. - Фаргона, 2007. - № 3. - Б. 55-59.
18. Л.В. Ильина, Б.Ш. Ризаев,Э.С. Жураев.Современные тенденции развитие и анализ эффективности использования легких бетонов. Труды Новосибирского государственного архитектурно-строительного университета. 2018 г.№ 4 - 29-36 с.
19. Л.В. Ильина, М.А. Раков, Б.Ш. Ризаев. Неавтоклавный газобетон из сухой сырьевой смеси. Труды Новосибирского государственного архитектурно-строительного университета. 2018 г. №3(69). -14-21с.
20. Мамадалиев Адхамжон Тухтамирзаевич. Теоретическое обоснование параметров чашеобразного дражирующего барабана. Universum:// Технические науки:электрон научн. журн. 2021. №6(87),-C.75-78.URL
21. Mamadaliyev Adxamjon Tuxtamirzayevich. Study of Pubescent Seeds Moving in a Stream of Water and Mineral Fertilizers. International Journal on Integrated Education 2020. 3(12), 489-493.
22. Мамадалиев Адхамжон Тухтамирзаевич. Уруглик чигитларни макро ва микроугитлар билан ^оби^ловчи ^урилманинг улчамлари ва иш режимларини асослаш. Мировая наука 2022. Международные коммуникации. Международная научно-практическая конференция. 12 января 2022. Новосибирск
23. М.Т. Абдуллаев, А.Т. Мамадалиев. Изучение эффективности дражирования семян хлопчатника в водном растворе минеральных удобрений и композиции микроэлементов. «Экономика и социум» 2022 № 1(92) С. 3-8.
24. Mamadaliev Adxamjon Tuxtamirzaevich - Presowing Treatment of Pubescent Cotton Seeds with a Protective and Nutritious Shell, Consisting of Mineral Fertilizers in an Aqueous Solution and a Composition of Microelements. Design Engineering, Vol 2021: Issue 09. 7046 - 7052.
25. Росабоев А.Т., Мамадалиев А.Т.(2017). Теоретическое обоснование движения опушенных семян хлопчатника после поступления из распределителяв процессе капсулирования. Science Time, (5), 239-245.
26. Росабоев А.Т., Мамадалиев А.Т., Тухтамирзаев А.А. У. (2017). Теоретическое обоснование параметров капсулирующего барабана опушенных семян. Science Time, (5 (41)), 246-249.
